Installing Retrofit and Replacement Vinyl Windows

Home
>
Home Improvement
>
Installing Retrofit and Replacement Vinyl Windows

Installing Retrofit and Replacement Vinyl Windows

In previous articles i explained to you how to determine whether your windows are candidates for vinyl replacement style frames or retrofit style frames. This week I'm going to explain the installation techniques for both frame styles. Let's start with the retrofit frame.

Retrofit window installation is really the easiest of all. The retrofit window already comes with an exterior trim attached. That's the flush fin that goes against the outside surface, usually stucco. Prepare the window by drilling 3/8" holes in the areas of the frame where you want to screw it in place. Normally, there will be 3 holes on each side and 3 more across the top. Don't predrill any holes in the bottom track. After removing the old panels, you want to run a heavy bead of caulk on the face of the old aluminum frame that you left in place. Then you and a helper set the bottom of the vinyl window onto the old aluminum bottom track and raise it into position. The flush fin or retrofit lip will act as a "stop" to hold the window in place. Have your helper hold the window while you go inside.

Once inside, you want to center the window in the opening. Slide the vent panel open and closed to make sure the window is plumb and level. To adjust for out of square conditions, shim the bottom right or left corner by placing a shimming material between the sill and bottom of the window frame. Once square, drive a 3" deck screw through the 3/8" holes and into the wood studs.Just seat the screw, don't overtighten. After you get the screws into the sides and top, remove the sliding panel. The bottom track should lift out. Look for drainage holes in the track and insert a thin screwdriver and lift up. Drive one screw in the bottom center, caulk around the screw head, then put the track back in place and re-install the sliding panel. Now, you want to go back outside and caulk the gap where the retrofit fin meets the exterior surface of the house. You want to have a double barrier of protection against water infiltration. Remember, you already applied a generous bead of caulk before inserting the new frame into the opening. The rest of the job is done on the inside.

First, you want to plug the 3/8" screw holes to hide the heads of the screws. We sell the hole plugs on the website. Just click on the "shop" tab to see a picture. The plugs will pop into place in the hole. The next step is to fill the gap around the new frame with R-13 Insulation. Do not use the foam insulation that comes in a can. Many manufacturers will not honor the warranty if the foam is used. Even the non expanding foams can cause the frame to distort, causing problems. Pack the insulation in tight. You might want to wear a dust mask during this procedure. Many people, myself included, are very sensitive to insulation. After the insulation is in place, you want to install trim around the inside to finish the job. You can use wood trim from the hardware store, or some other product. But in my experience, the best product is a vinyl flat trim that matches the window frame. The flat trim can also be purchased on the website under the "shop" tab, or you could try to find it from a local window contractor. Ours comes in 3 different widths, although the 1 3/4" wide piece is by far the most common. The trim has a double sided adhesive tape on the back. You cut the top and bottom first, stick them on the vinyl frame, making sure the trim goes to the drywall. This covers all the insulation and the old metal frame. Do the side pieces next. The final step is to caulk where the trim meets the walls.

Much of the installation process for a replacement frame is the same as the retrofit frame. But, there are a few differences. When you put the new window into the opening using a replacement frame, you don't have the flush fin holding the frame in place. You and your helper have to hold the frame in place while you put a screw in the top center to support the frame. Then, you can do your adjusting for a square condition. All of the procedures on the inside will be exactly the same, from hole plugs, to insulation, to trim and caulk. The outside is different. You have to apply the trim that was part of the retrofit frame. Again, I prefer the flat trim. Once again, you apply a bead of caulk to the old frame,then measure and cut the top and bottom trim pieces. Apply the adhesive part of the trim to the vinyl frame, and let the other part contact the bead of caulk. Trim all four sides, then caulk again where the trim meets the exterior material.

As you can see, it really doesn't matter if the exterior of your home is brick, stone, siding, or stucco. You can install vinyl windows without having to damage the surrounding structure. We have step by step instructional videos for sale on the website at how-to-install-windows.com. Next week we are going to start discussing sliding glass door replacement.

John Rocco has been installing replacement windows since 1978. To learn more, visit How To Install Windows

In The News:

Yahoo! News: Top Stories

Geithner likely treasury pick; Clinton 'on track' (AP)

AP - President-elect Barack Obama intends to name Timothy Geithner, president of the New York Federal Reserve, as his treasury secretary to confront the nation's intense economic turmoil, senior Democratic officials said Friday.

Bush rallies China's help on North Korea (AP)

AP - In a last dash of diplomacy, President George W. Bush on Friday sought China's help in pinning down North Korea to keep its shaky promises of nuclear disarmament.

Obama keeps low profile in auto rescue talks (AP)

AP - While President-elect Barack Obama publicly sidelined himself during congressional debate over an auto industry bailout this week, he and his top aides quietly prodded congressional leaders to find a solution to rescue struggling automakers.

Neb. lawmakers OK age limit for safe-haven law (AP)

AP - Gov. Dave Heineman signed into law Friday a bill adding a 30-day age limit to a safe-haven law that allowed 35 children including teenagers as old as 17 to be abandoned at state hospitals. The law, approved hours earlier by the Legislature in a 45-3 vote, goes into effect Saturday, and makes Nebraska the 14th state with a 30-day age cap. It had been the only state with a safe-haven law without an age limit.

Germany drops attempt to ban Scientology (AP)

AP - Germany is dropping its pursuit of a ban on Scientology after finding insufficient evidence of illegal activity, security officials said Friday.

Gates would like to add US forces in Afghanistan (AP)

AP - Defense Secretary Robert Gates said Friday he would like to add significant U.S. forces to the war in Afghanistan before national elections scheduled for next year, and that grim depictions of backsliding in the seven-year-old war are "far too pessimistic."

Fla. teen commits suicide with live Web audience (AP)

AP - A college student committed suicide by taking a drug overdose in front of a live webcam as some computer users egged him on, others tried to talk him out of it, and another messaged OMG in horror when it became clear it was no joke. Some watchers contacted the Web site to notify police, but by the time officers entered Abraham Biggs' home a scene also captured on the Internet it was too late.

Lavish 1,800 year-old bronze chariot unearthed in Bulgaria (AP)

AP - Archaeologists have unearthed an elaborately decorated 1,800-year-old chariot sheathed in bronze at an ancient Thracian tomb in southeastern Bulgaria, the head of the excavation said Friday. "The lavishly ornamented four-wheel chariot dates back to the end of the second century A.D.," Veselin Ignatov told The Associated Press in a telephone interview from the site, near the southeastern village of Karanovo.

Suspect arrested for greasy imprints in Neb. town (AP)

AP - Police have arrested a man suspected of leaving greasy, graphic imprints on the windows of stores, churches and schools in a small Nebraska town. A 35-year-old man was caught in the act by police early Wednesday morning, Cherry County Attorney Eric Scott said Friday. The man hasn't been charged yet, but authorities believe he is the vandal some townsfolk have dubbed the "Butt Bandit."

Knicks set themselves up for 2010 with 2 deals (AP)

AP - The New York Knicks traded Zach Randolph and Jamal Crawford in separate deals Friday, parting with their two top scorers to free up coveted salary-cap space for the summer of 2010. Crawford was sent to Golden State for forward Al Harrington. Hours later, Randolph was shipped to the Los Angeles Clippers along with reserve guard Mardy Collins for Cuttino Mobley and Tim Thomas.

Obama moves to pick Timothy Geithner for Treasury (Reuters)

Reuters - President-elect Barack Obama on Friday moved toward nominating Timothy Geithner as Treasury secretary and charging the respected head of the New York Federal Reserve with helping pull the United States out of an economic nosedive.

Citigroup talking to U.S. government as shares dive: source (Reuters)

Reuters - Citigroup Inc has begun talks with the U.S. government as its plummeting share price raises doubts about the bank's ability to survive, a person familiar with the matter said.

GM cuts output, jets as U.S. demands turnaround plans (Reuters)

Reuters - Detroit automakers began work on turnaround plans demanded by Congress in return for $25 billion in aid as General Motors Corp said it would cut production more and give up two of its controversial corporate jets.

General Motors board weighs bankruptcy option: report (Reuters)

Reuters - The board of directors of embattled U.S. automaker General Motors Corp is considering "all options" including bankruptcy, according to a report on the Wall Street Journal's website late on Friday.

Wall Street stages late rally on Geithner news (Reuters)

Reuters - U.S. stocks stormed higher in a late rally on Friday to cap another volatile week as investors welcomed reports that President-elect Barack Obama has chosen his point person to combat the U.S. economic crisis, instilling confidence about the administration's ability to take action.

U.S. eyes "surge" of over 20,000 for Afghanistan (Reuters)

Reuters - The Pentagon is considering a plan to send more than 20,000 troops to Afghanistan over the next 12 to 18 months to help safeguard elections and quell rising Taliban violence, officials said on Friday.

U.S. Bancorp acquires deposits of failed Downey, PFF (Reuters)

Reuters - U.S. banking regulators seized California banks Downey Savings and Loan and PFF Bank & Trust late Friday as the housing crisis claimed two more victims from the financial crisis.

Suspected U.S. missile strike kills 4 in Pakistan (Reuters)

Reuters - A suspected U.S. drone aircraft fired a missile in the North Waziristan tribal region of Pakistan killing at least four people, according to Pakistani intelligence officials.

Obama readies economic team as global recession fears rise (AFP)

AFP - The economic team of US president-elect Barack Obama came into view as fears mounted on the global financial crisis and more mass job cuts loomed worldwide.

Bush bows out, China assertive at APEC summit (AFP)

AFP - US President George W. Bush began Friday his last scheduled foreign trip, meeting the leader of increasingly important China ahead of a summit aimed at containing a spiraling financial crisis.

Installing Retrofit and Replacement Vinyl Windows

Home Improvement Home Improvement