Removing Old Aluminum Windows

Home
>
Home Improvement
>
Removing Old Aluminum Windows

Removing Old Aluminum Windows

This week we are going to talk about the process of actually removing your aluminum windows in preparation for installing vinyl replacement windows. Let's start with a horizontal sliding window, which is pretty common nationwide. There is going to be a sliding panel and a stationary panel. You want to remove the slider first. All you do is slide the panel open, grab the sides of the panel with your hands,lift up and swing out. Under ideal circumstances, it would be that easy. However, there are small obstacles that can prevent you from lifting out the panel.

Many sliding windows have rollers on the top as well as the bottom. The top rollers don't actually do anything, they are there more as spares to replace the bottom rollers when they wear out. But many times the window installer will adjust these top rollers to prevent anyone from lifting out the panel. If this is the case with your windows, there will be a screw at the top of each side rail. If you loosen these screws, then lift up on the panel, it should come out. Another obstacle involves a little piece of rubber that the manufacturer places in the top track. This rubber piece has the same effect as adjusting the top rollers. It prevents you from lifting out the panel because it's wedged between the top of the window panel and the top of the upper track. If you can see that the window panel isn't lifting all the way up in the top track, and the top rollers are not the reason, then you have to dig out that rubber piece. It's usually at the point in the center, where the sliding panel and fixed panel overlap when the window is closed. Reach in there with a long, thin screwdriver, and try to pry it out.

Once you have the slider out, take out the screen. You can just pull it out. No need to be gentle since you're throwing it away anyway. The last step is the fixed panel removal. There are a few different applications here. All of them will have a center vertical bar. It's usually there to accept the locking mechanism on the slider, but not always. Look for screws holding this center bar in place. They will either be on the outside top and bottom, or you might find them on the side channel where the screen would go. Check the top and bottom corners.

Assuming you found the screws and removed them, you now need to take the center bar off. Take a screw driver and a hammer and tap the center bar at the very bottom. Tap it off the fixed panel frame. Now, pull the fixed panel away from the side where it rests in the side channel. What you are trying to do is slide the fixed panel open the same way that you did the sliding panel. Then, you can lift the fixed panel up and out. Sometimes, the fixed panel won't want to slide open because it has gotten stuck in the side track. You can put a screw driver into the side channel and pry the fixed panel away from the side. It doesn't matter if you bend the frame that's still attached to the house, because we are going to hide all of that anyway.

Now, let's go back to the vertical center bar and assume you didn't find any screws to remove it. That means the fixed piece of glass doesn't have a frame around it. It's glazed in with either silicone, caulk, or double foam tape. You have to take out the glass, then cut the center bar out using a reciprocating saw. Usually, there will be "stops" on the outside to help keep the fixed piece of glass in place. There will be 4 of them, one on top, bottom, and each side. You should be able to just pry them out with a screw driver. Then, you can go inside and cut away the adhesive holding the glass in the frame. Use a utility knife and cut between the glass and frame. Wear gloves, and be careful not to put your hand through the glass. Put a sheet or tarp outside and let the glass fall into it. You could also have a helper stand on a ladder above the glass and try grabbing the top edge as you cut it away from the frame. Have your helper also wear gloves. The reason for the ladder is that you want to be above the glass in case it has a little crack that you can't see. As soon as you grab the glass, the crack will run across to the opposite edge, and suddenly you will find yourself trying to hold multiple pieces of glass at the same time. Being on the ladder, if the glass "runs", you let go. After the glass is out, cut the bottom portion of the center bar flush with the bottom track. Then, you can wiggle the bar back and forth to break the top screw free. You can apply this removal process to picture windows that have no sliding panel. Just treat it like you did the fixed portion, without having to remove a center bar.

Next week we will talk about the installation differences between a vinyl replacement frame and a vinyl retrofit frame.

John Rocco has been installing replacement windows since 1978. To learn more, visit How To Install Windows

In The News:

Yahoo! News: Top Stories

Gaza fighting rages despite cease-fire proposal (AP)

AP - Israel resumed its Gaza offensive Wednesday, bombing heavily around suspected smuggling tunnels near the border with Egypt after a three-hour lull to allow in humanitarian aid. Hamas responded with a rocket barrage. Despite the heavy fighting, strides were made on the diplomatic front with the U.S. throwing its weight behind a deal being brokered by France and Egypt.

Obama taps spending watchdog, eyes Social Security (AP)

AP - Pointing with concern to "red ink as far as the eye can see," President-elect Barack Obama pledged Wednesday to tackle out-of-control Social Security and Medicare spending and named a special watchdog to clamp down on other federal programs even as he campaigned anew to spend the largest pile of taxpayer money in history to revive the sinking economy.

Senate Democrats yield to Obama, retreat on Burris (AP)

AP - Senate Democrats beat a hasty retreat Wednesday from their rejection of Roland Burris as President-elect Barack Obama's successor, yielding to pressure from Obama himself and from senators irked that the standoff was draining attention and putting them in a bad light. Burris said with a smile he expected to join them "very shortly."

Melting snow causes heavy flooding in Wash. state (AP)

AP - Rain and high winds lashed Washington state Wednesday, causing widespread avalanches, mudslides, flooding and road closures as the heavy snowfall that has buried parts of the state began to rapidly melt. More than 30,000 people were told to leave their homes in a flood-endangered valley southeast of Tacoma, as authorities warned of heavy flooding.

Obama hails 'extraordinary' moment with presidents (AP)

AP - Confronting a grim economy and a Middle East on fire, Barack Obama turned Wednesday to perhaps the only people on the planet who understand what he's in for: the four living members of the U.S. presidents' club.

Feds say inauguration attractive terrorist target (AP)

AP - The upcoming inauguration of Barack Obama is an attractive target for international and domestic terrorists, but U.S. intelligence officials have no information about specific threats to the Jan. 20 event.

Drug made from genetically engineered goats may become scientific first (AP)

AP - You've heard of making cheese from goats' milk, but prescription drugs? In what would be a scientific first, an anti-clotting drug made from the milk of genetically engineered goats moved closer to government approval Wednesday after experts at the Food and Drug Administration reported that the medication works and its safety is acceptable.

DeGeneres wins at People's Choice Awards (AP)

AP - Ellen DeGeneres and "Dancing with the Stars" were early winners at the People's Choice Awards.

Pa. man opens neighbor's door with chain saw (AP)

AP - An eastern Pennsylvania man may face up to 37 years in prison for tearing open a neighbor's door with a chain saw. Police say 34-year-old Robert Kane began sawing through the front door of Jamie Zaleski's apartment in Scranton while Zaleski and several friends ran out the back.

AP source: Browns to hire Eric Mangini as coach (AP)

AP - Eric Mangini is the new head coach of the Cleveland Browns, a week after being fired by the New York Jets. A person with knowledge of the negotiations told The Associated Press that Mangini will be introduced Thursday at a news conference at the team's headquarters in Berea.

Israel bombards Gaza, U.S. backs ceasefire plan (Reuters)

Reuters - Israeli warplanes bombed the Gaza Strip on Thursday and tanks pounded Palestinian guerrillas on the ground as U.S. backing for a proposed truce raised expectations of an end to the offensive.

Budget deficit to hit $1.2 trillion in fiscal 2009 (Reuters)

Reuters - The U.S. budget deficit will swell to a record $1.186 trillion in fiscal 2009, congressional forecasters said on Wednesday, the result of an economic recession that has cut tax receipts and caused massive government bailouts of banks and automakers.

Senate Democrats move to seat Burris (Reuters)

Reuters - In an abrupt switch, Democratic leaders began talks on Wednesday to swear in Roland Burris, appointed by embattled Illinois Gov. Rod Blagojevich to replace President-elect Barack Obama in the U.S. Senate.

Union gears up for negotiations with GM and Chrysler (Reuters)

Reuters - United Auto Workers bargaining teams are arriving this week in Detroit as the union gears up for negotiations with General Motors Corp and Chrysler LLC, which are mandated to cut labor costs under a $17.4 billion federal bailout.

Mumbai-like attack could happen in U.S.: Bush aide (Reuters)

Reuters - U.S. cities are vulnerable to an attack like the gun-and-grenade assault that terrorized Mumbai for three days and killed 179 people, the White House homeland security adviser said on Wednesday.

"Enemy combatant" will be early test for Obama (Reuters)

Reuters - The case of Ali al-Marri, accused of being an al Qaeda "sleeper" agent and held for 5-1/2 years at a U.S. military prison in South Carolina, will be an early test for President-elect Barack Obama.

Salmonella outbreak sickens 388 across U.S.: health officials (Reuters)

Reuters - An outbreak of salmonella food poisoning has made 388 people sick across 42 states, sending 18 percent of them to the hospital, U.S. health officials said on Wednesday.

U.S. presses to jail Madoff on diamonds, watches mail (Reuters)

Reuters - Accused swindler Bernard Madoff should be jailed for violating a court order by mailing $1 million worth of diamonds, watches and other jewelry to friends and family, U.S. prosecutors told a court on Wednesday.

Israel approves tougher war on Hamas (AFP)

AFP - Israel on Wednesday approved an even tougher war on Hamas, warning residents to flee southern Gaza ahead of planned bombing of cross-border tunnels, as the Palestinian death toll passed 700.

Kremlin lays down terms as gas crisis engulfs Europe (AFP)

AFP - Russian President Dmitry Medvedev on Wednesday laid down terms for a resumption of Russian gas shipments via Ukraine to Europe as tens of thousands of Europeans suffered heating cuts amid freezing weather.

Removing Old Aluminum Windows

Home Improvement Home Improvement