Removing Your Old Sliding Glass Door

Home
>
Home Improvement
>
Removing Your Old Sliding Glass Door

Removing Your Old Sliding Glass Door

Last week I explained how to measure your existing sliding glass door so you can order the vinyl replacement door. This week I am going to go over the steps required to remove the old sliding door before installing the new door.

First, you have to remove the sliding panel and the stationary panel. The vast majority of doors out there have the sliding panel on the inside half of the track, and the stationary panel is on the outside. Whatever the case in your particular door, the outside panel has to come out first. To remove the fixed panel, you need to remove the sill cap that snaps into the bottom track and runs from the fixed panel to the side jamb where the sliding panel locks. Force a screwdriver into the crease and pry the cap up. Then, look for screws on the inside side jamb holding the fixed panel in place. These screws prevent someone from prying up the sill cap and pulling out the fixed panel in order to gain entry into the home. In addition to the side jamb, be sure to check across the top header and bottom track for screws there as well. Once all the screws have been removed, you need to pull the fixed panel away from the side jamb. You can start by simply grabbing the side rail of the fixed panel and pulling as hard as you can. If you're lucky, the panel will pop free. Then you can lift the panel up as far as it will go into the top channel and swing the bottom away from the track, and remove the panel.

Now, I said "if you're lucky", because in most cases the panel will be stuck in the side jamb, the bottom track, or both. Usually, you're going to have to use a pry bar to loosen the fixed panel before it will slide out of the side jamb. Once the fixed panel is out, removal of the sliding panel is usually easier. Just lift up and swing the bottom away from the track, then remove the panel. Sometimes the bottom rollers will prevent the bottom from swinging out of the track. If that's the case, you will need to find the roller adjustment hole in the bottom corners of the sliding panel. Put a screwdriver into this hole and turn the screw counterclockwise to bring the roller as far up into the bottom of the sliding panel as possible. This should allow the slider to come out.

Now, you want to remove all the screws from the side jambs, top header, and bottom track. Then, take a pry bar and get it under the bottom track about in the center. Pry up until the track is separated from the floor. The next step will depend on whether your old frame is nailed to the house frame, or simply screwed in. If it's screwed in, then the frame should now be loose in the opening, since you removed all of the screws. You just need to remove whatever inside trim there might be around the door frame. This type of frame should come out. If your door is nailed to the house frame, you will have to do a bit more work. Use a hacksaw to cut the track in half, approximately in the center. Start with either half and raise the cut piece up towards the side jamb until the the track piece separates from the side jamb. Do the same thing to the other half.

So, now you have to remove the side jambs. You want to do this without damaging the exterior material that surrounds the door frame. Take a heavy chisel and pound it into the crack between the frame and exterior material, whether it's stucco, siding, etc. Start at the bottom 6 inches first. What you are trying to do is pull the nail fin away from the nails holding it in place. So, once the chisel is pounded through the metal frame, pry away from the side wall. The heavier and longer the chisel, the more leverage you will have. You will hear the frame "pop" free of the nail. There will be several nails holding each jamb in place, so you want to start at the bottom and work your way to the top corner. Once you get the bottom third loose, many times you can grab the jamb with both hands and pull the rest of the nails free as you go up. When you get to the top corner, work the jamb free. Do both jambs, then do the top. Sometimes the top has no nails, or just one in the center, so it will come down pretty easily. Be sure to wear safety glasses and a dust mask when doing this job, especially when removing the top header.

At this point you are ready to install the new door. The installation procedure is slightly different, depending on whether you're installing a retrofit style frame or a replacement frame. We will discuss both procedures next week.

John Rocco has been installing replacement windows since 1978. To learn more, visit How To Install Windows

In The News:

Yahoo! News: Top Stories

Gaza fighting rages despite cease-fire proposal (AP)

AP - Israel resumed its Gaza offensive Wednesday, bombing heavily around suspected smuggling tunnels near the border with Egypt after a three-hour lull to allow in humanitarian aid. Hamas responded with a rocket barrage.

Obama taps spending watchdog, eyes Social Security (AP)

AP - Pointing with concern to "red ink as far as the eye can see," President-elect Barack Obama pledged Wednesday to tackle out-of-control Social Security and Medicare spending and named a special watchdog to clamp down on other federal programs even as he campaigned anew to spend the largest pile of taxpayer money in history to revive the sinking economy.

Senate Democrats yield to Obama, retreat on Burris (AP)

AP - Senate Democrats beat a hasty retreat Wednesday from their rejection of Roland Burris as President-elect Barack Obama's successor, yielding to pressure from Obama himself and from senators irked that the standoff was draining attention and putting them in a bad light. Burris said with a smile he expected to join them "very shortly."

Melting snow causes heavy flooding in Wash. state (AP)

AP - Rain and high winds lashed Washington state Wednesday, causing widespread avalanches, mudslides, flooding and road closures as the heavy snowfall that has buried parts of the state began to rapidly melt.

Obama hails 'extraordinary' moment with presidents (AP)

AP - Confronting a grim economy and a Middle East on fire, Barack Obama turned Wednesday to perhaps the only people on the planet who understand what he's in for: the four living members of the U.S. presidents' club.

Feds say inauguration attractive terrorist target (AP)

AP - The upcoming inauguration of Barack Obama is an attractive target for international and domestic terrorists, but U.S. intelligence officials have no information about specific threats to the Jan. 20 event.

Drug made from genetically engineered goats may become scientific first (AP)

AP - You've heard of making cheese from goats' milk, but prescription drugs? In what would be a scientific first, an anti-clotting drug made from the milk of genetically engineered goats moved closer to government approval Wednesday after experts at the Food and Drug Administration reported that the medication works and its safety is acceptable.

DeGeneres wins at People's Choice Awards (AP)

AP - Ellen DeGeneres and "Dancing with the Stars" were early winners at the People's Choice Awards.

Lin leads Harvard to 82-70 upset over No. 17 BC (AP)

AP - Jeremy Lin scored 27 points to lead Harvard to an 82-70 upset over No. 17 Boston College on Wednesday night, three days after the Eagles upset previously top-ranked North Carolina.

AP source: Browns to hire Eric Mangini as coach (AP)

AP - Eric Mangini is the new head coach of the Cleveland Browns, a week after being fired by the New York Jets. A person with knowledge of the negotiations told The Associated Press that Mangini will be introduced Thursday at a news conference at the team's headquarters in Berea.

Israel bombards Gaza, U.S. backs ceasefire plan (Reuters)

Reuters - Israeli warplanes bombed the Gaza Strip on Thursday and tanks pounded Palestinian guerrillas on the ground as U.S. backing for a proposed truce raised expectations of an end to the offensive.

Budget deficit to hit $1.2 trillion in fiscal 2009 (Reuters)

Reuters - The U.S. budget deficit will swell to a record $1.186 trillion in fiscal 2009, congressional forecasters said on Wednesday, the result of an economic recession that has cut tax receipts and caused massive government bailouts of banks and automakers.

Senate Democrats move to seat Burris (Reuters)

Reuters - In an abrupt switch, Democratic leaders began talks on Wednesday to swear in Roland Burris, appointed by embattled Illinois Gov. Rod Blagojevich to replace President-elect Barack Obama in the U.S. Senate.

Union gears up for negotiations with GM and Chrysler (Reuters)

Reuters - United Auto Workers bargaining teams are arriving this week in Detroit as the union gears up for negotiations with General Motors Corp and Chrysler LLC, which are mandated to cut labor costs under a $17.4 billion federal bailout.

Mumbai-like attack could happen in U.S.: Bush aide (Reuters)

Reuters - U.S. cities are vulnerable to an attack like the gun-and-grenade assault that terrorized Mumbai for three days and killed 179 people, the White House homeland security adviser said on Wednesday.

"Enemy combatant" will be early test for Obama (Reuters)

Reuters - The case of Ali al-Marri, accused of being an al Qaeda "sleeper" agent and held for 5-1/2 years at a U.S. military prison in South Carolina, will be an early test for President-elect Barack Obama.

Salmonella outbreak sickens 388 across U.S.: health officials (Reuters)

Reuters - An outbreak of salmonella food poisoning has made 388 people sick across 42 states, sending 18 percent of them to the hospital, U.S. health officials said on Wednesday.

U.S. presses to jail Madoff on diamonds, watches mail (Reuters)

Reuters - Accused swindler Bernard Madoff should be jailed for violating a court order by mailing $1 million worth of diamonds, watches and other jewelry to friends and family, U.S. prosecutors told a court on Wednesday.

Lenovo to cut 2,500 jobs amid global slowdown (AFP)

AFP - Chinese computer giant Lenovo announced Thursday it would cut about 2,500 jobs, roughly 11 percent of its worldwide workforce, after suffering losses due to the global economic crisis.

Israel approves tougher war on Hamas (AFP)

AFP - Israel on Wednesday approved an even tougher war on Hamas, warning residents to flee southern Gaza ahead of planned bombing of cross-border tunnels, as the Palestinian death toll passed 700.

Removing Your Old Sliding Glass Door

Home Improvement Home Improvement