Single Pane Glass Repair in an Aluminum Frame, Part 2

Home
>
Home Improvement
>
Single Pane Glass Repair in an Aluminum Frame, Part 2

Single Pane Glass Repair in an Aluminum Frame, Part 2

This week we are going to continue our series on single pane window glass repair. Let's talk about broken glass in a fixed window, usually referred to as a picture window. The most common type will have metal stops on the outside, around all four edges of the window glass. Sometimes these stops will be held in place with screws, and other times there will be aluminum stops that snap in place. In some rare instances there will be a rubber material in place of metal. If you have the screw type, you remove all of the screws and each piece will come out. If you have the metal snap in stops, carefully pry the stop from the frame using a small, flat screwdriver or a putty knife. You want to start in a corner and work along the stop until it comes out. Don't pry too much because the stops can bend very easily. If you have the rubber type, pry a corner away using the screwdriver, grab it with your fingers, and pull out the rubber. The glass shouldn't fall out because there is a glue or tape on the edge, holding the glass in place.

From here, You can get your measurements for the new piece of glass. The glass edges will be exposed, and you can hook your tape measure to the edge and get your width and height. If there is a hole in the glass, measure the glass thickness. If there isn't a hole, put on some gloves and carefully push on the glass where the crack is located. This will expose the edge so you can measure it. When you go to get the new glass, you're going to need a tube of silicone to replace the glue or tape holding the glass in place. Once you get the glass home, you need to remove the old glass. Go inside and cut between the glass and frame using a utility knife with a new blade. This will cut away the silicone or tape that is holding the old glass. Be sure to wear heavy gloves during this process to avoid getting cut. Start at the top and cut across from one corner to the other. Then cut down one side, from top to bottom. Do the other side the same way. At this point the glass should fall out. You should place a tarp or sheet under the window to catch the glass as it falls out. Using a stiff putty knife, scrape off the old silicone or tape from the frame. If there were setting blocks on the bottom, be sure to reuse them. They act as shims to raise the glass off the bottom.

Now run a bead of silicone about 3/16" thick around the perimeter of the opening. Grab your new glass on the sides, angle the bottom in and the top out, set the glass on the setting blocks, then slowly raise the glass up into place. Push just hard enough that all four edges of the glass contact the silicone, but not so hard that the glass makes contact with the metal frame. Install your outside stops. Don't clean the glass for 24 hours so the silicone can set up.

Next week I will continue this series on window glass repair.

John Rocco has been installing replacement windows since 1978. To learn more, visit How To Install Windows

In The News:

Yahoo! News: Top Stories

Gaza fighting rages despite cease-fire proposal (AP)

AP - Israel resumed its Gaza offensive Wednesday, bombing heavily around suspected smuggling tunnels near the border with Egypt after a three-hour lull to allow in humanitarian aid. Hamas responded with a rocket barrage.

Obama taps spending watchdog, eyes Social Security (AP)

AP - Pointing with concern to "red ink as far as the eye can see," President-elect Barack Obama pledged Wednesday to tackle out-of-control Social Security and Medicare spending and named a special watchdog to clamp down on other federal programs even as he campaigned anew to spend the largest pile of taxpayer money in history to revive the sinking economy.

Senate Democrats yield to Obama, retreat on Burris (AP)

AP - Senate Democrats beat a hasty retreat Wednesday from their rejection of Roland Burris as President-elect Barack Obama's successor, yielding to pressure from Obama himself and from senators irked that the standoff was draining attention and putting them in a bad light. Burris said with a smile he expected to join them "very shortly."

Melting snow causes heavy flooding in Wash. state (AP)

AP - Rain and high winds lashed Washington state Wednesday, causing widespread avalanches, mudslides, flooding and road closures as the heavy snowfall that has buried parts of the state began to rapidly melt.

Obama hails 'extraordinary' moment with presidents (AP)

AP - Confronting a grim economy and a Middle East on fire, Barack Obama turned Wednesday to perhaps the only people on the planet who understand what he's in for: the four living members of the U.S. presidents' club.

Feds say inauguration attractive terrorist target (AP)

AP - The upcoming inauguration of Barack Obama is an attractive target for international and domestic terrorists, but U.S. intelligence officials have no information about specific threats to the Jan. 20 event.

Drug made from genetically engineered goats may become scientific first (AP)

AP - You've heard of making cheese from goats' milk, but prescription drugs? In what would be a scientific first, an anti-clotting drug made from the milk of genetically engineered goats moved closer to government approval Wednesday after experts at the Food and Drug Administration reported that the medication works and its safety is acceptable.

DeGeneres wins at People's Choice Awards (AP)

AP - Ellen DeGeneres and "Dancing with the Stars" were early winners at the People's Choice Awards.

Lin leads Harvard to 82-70 upset over No. 17 BC (AP)

AP - Jeremy Lin scored 27 points to lead Harvard to an 82-70 upset over No. 17 Boston College on Wednesday night, three days after the Eagles upset previously top-ranked North Carolina.

AP source: Browns to hire Eric Mangini as coach (AP)

AP - Eric Mangini is the new head coach of the Cleveland Browns, a week after being fired by the New York Jets. A person with knowledge of the negotiations told The Associated Press that Mangini will be introduced Thursday at a news conference at the team's headquarters in Berea.

Israel bombards Gaza, U.S. backs ceasefire plan (Reuters)

Reuters - Israeli warplanes bombed the Gaza Strip on Thursday and tanks pounded Palestinian guerrillas on the ground as U.S. backing for a proposed truce raised expectations of an end to the offensive.

Senate Democrats move to seat Burris (Reuters)

Reuters - In an abrupt switch, Democratic leaders began talks on Wednesday to swear in Roland Burris, appointed by embattled Illinois Gov. Rod Blagojevich to replace President-elect Barack Obama in the U.S. Senate.

Budget deficit to hit $1.2 trillion in fiscal 2009 (Reuters)

Reuters - The U.S. budget deficit will swell to a record $1.186 trillion in fiscal 2009, congressional forecasters said on Wednesday, the result of an economic recession that has cut tax receipts and caused massive government bailouts of banks and automakers.

Mumbai-like attack could happen in U.S.: Bush aide (Reuters)

Reuters - U.S. cities are vulnerable to an attack like the gun-and-grenade assault that terrorized Mumbai for three days and killed 179 people, the White House homeland security adviser said on Wednesday.

"Enemy combatant" will be early test for Obama (Reuters)

Reuters - The case of Ali al-Marri, accused of being an al Qaeda "sleeper" agent and held for 5-1/2 years at a U.S. military prison in South Carolina, will be an early test for President-elect Barack Obama.

Salmonella outbreak sickens 388 across U.S.: health officials (Reuters)

Reuters - An outbreak of salmonella food poisoning has made 388 people sick across 42 states, sending 18 percent of them to the hospital, U.S. health officials said on Wednesday.

U.S. presses to jail Madoff on diamonds, watches mail (Reuters)

Reuters - Accused swindler Bernard Madoff should be jailed for violating a court order by mailing $1 million worth of diamonds, watches and other jewelry to friends and family, U.S. prosecutors told a court on Wednesday.

Russia, Ukraine take gas row case to Europe (Reuters)

Reuters - Russia and Ukraine argue their case to Europe on Thursday in a gas price dispute that has choked off energy supplies to EU countries beset by bitter winter weather.

Israel approves tougher war on Hamas (AFP)

AFP - Israel on Wednesday approved an even tougher war on Hamas, warning residents to flee southern Gaza ahead of planned bombing of cross-border tunnels, as the Palestinian death toll passed 700.

Russia, Ukraine in EU talks as gas crisis engulfs Europe (AFP)

AFP - Envoys from Russia and Ukraine go to Brussels on Thursday for emergency EU-brokered talks to resolve a bitter gas fight between the two ex-Soviet giants that has engulfed Europe in a major energy crisis.

Single Pane Glass Repair in an Aluminum Frame, Part 2

Home Improvement Home Improvement