Single hung aluminum window glass repair

Home
>
Home Improvement
>
Single hung aluminum window glass repair

Single hung aluminum window glass repair

Let's talk about repairing broken glass in an aluminum frame single hung window. If it's the lower sash pane that is broken, it must be removed from the inside. You are going to have one of three different mechanisms that hold the lower sash up when you slide it open. If you can't see any mechanisms on the sides, then you have a block and tackle system consisting of a string and spring assembly. Find the thin metal clips in the side jambs just above the sash. Pull the bottom of the clip out using a screwdriver or your fingernail. Do that on both sides. Then remove any rubber stops at the very top of the window. Raise the window as high as it will go. The block and tackle assemblies will get snagged in the metal clips, allowing you to remove the window sash. You would replace the glass using the same method described in our article about sliding window repairs. Once you have the new glass installed, install the window panel in the reverse order that you removed it. Close the window and push the metal clips back. Install the rubber stops at the top.

If you have a mechanism across the top of the window with a string coming down each side and screwed into the top corners of the window sash, you need to remove the screws holding the strings in place. But before you remove the screws, you need to remove one of the black plastic pieces that cover the side jamb. Raise the window all the way up, then put a flat screwdriver at the very bottom of the plastic piece and pull outward until you can grab it with your fingers. Slide the plastic out. Now remove the screws holding the strings. Be sure to hold the string in one hand while removing the screw, because the string is under tension. After removing the screw, let the string slowly go back up. Pull the panel to the side that you removed the black plastic piece, and remove the panel. Remember, two of your corner screws will be removed at this point, and the proper way to remove the frame from the glass is to remove opposite corner screws. So, you should put one of the string screws back in and remove the corner screw opposite the removed string screw. Then, when you install the new glass, remove the string screw and install the strings. Raise the window up and install the black plastic piece by sliding it up between the frame and side jamb.

The final mechanism will be a spiral metal rod. If you have this type, i suggest you have it done by a professional. If you aren't careful with these, you can wind up having to replace the spiral rods. Now, if the broken pane is the upper sash, more than likely it will be a fixed panel. You can take these out without messing with the sliding panel. Unlock the window and raise the lower sash a few inches. Remove the screen, then remove the two screws holding the horizontal bar on place. Tap the bar down in one corner using a hammer and screwdriver. The bar will come off. Then you can grab the bottom of the upper sash and wiggle as you pull the sash downward. Once you have pulled it down several inches, you should be able to grab the top and bottom of the sash and pull to the left or right until the opposite side comes out. Then you can swing the panel out.

Once the new glass is installed, you can put the upper sash back by reversing the removal procedure. Tap the bottom upward with a hammer or rubber mallet, ensuring that the sash is fully seated in the top of the frame. Then, put the horizontal mulling bar back in place and tap it on the sash framer. Install the screws and screen. You're done. Next week we will cover broken glass repair of dual pane windows.

John Rocco has been installing replacement windows since 1978. To learn more, visit How To Install Windows

In The News:

Yahoo! News: Top Stories

Gaza fighting rages despite cease-fire proposal (AP)

AP - Israel resumed its Gaza offensive Wednesday, bombing heavily around suspected smuggling tunnels near the border with Egypt after a three-hour lull to allow in humanitarian aid. Hamas responded with a rocket barrage.

Obama taps spending watchdog, eyes Social Security (AP)

AP - Pointing with concern to "red ink as far as the eye can see," President-elect Barack Obama pledged Wednesday to tackle out-of-control Social Security and Medicare spending and named a special watchdog to clamp down on other federal programs even as he campaigned anew to spend the largest pile of taxpayer money in history to revive the sinking economy.

Senate Democrats yield to Obama, retreat on Burris (AP)

AP - Senate Democrats beat a hasty retreat Wednesday from their rejection of Roland Burris as President-elect Barack Obama's successor, yielding to pressure from Obama himself and from senators irked that the standoff was draining attention and putting them in a bad light. Burris said with a smile he expected to join them "very shortly."

Melting snow causes heavy flooding in Wash. state (AP)

AP - Rain and high winds lashed Washington state Wednesday, causing widespread avalanches, mudslides, flooding and road closures as the heavy snowfall that has buried parts of the state began to rapidly melt.

Obama hails 'extraordinary' moment with presidents (AP)

AP - Confronting a grim economy and a Middle East on fire, Barack Obama turned Wednesday to perhaps the only people on the planet who understand what he's in for: the four living members of the U.S. presidents' club.

Feds say inauguration attractive terrorist target (AP)

AP - The upcoming inauguration of Barack Obama is an attractive target for international and domestic terrorists, but U.S. intelligence officials have no information about specific threats to the Jan. 20 event.

Drug made from genetically engineered goats may become scientific first (AP)

AP - You've heard of making cheese from goats' milk, but prescription drugs? In what would be a scientific first, an anti-clotting drug made from the milk of genetically engineered goats moved closer to government approval Wednesday after experts at the Food and Drug Administration reported that the medication works and its safety is acceptable.

DeGeneres wins at People's Choice Awards (AP)

AP - Ellen DeGeneres and "Dancing with the Stars" were early winners at the People's Choice Awards.

Lin leads Harvard to 82-70 upset over No. 17 BC (AP)

AP - Jeremy Lin scored 27 points to lead Harvard to an 82-70 upset over No. 17 Boston College on Wednesday night, three days after the Eagles upset previously top-ranked North Carolina.

AP source: Browns to hire Eric Mangini as coach (AP)

AP - Eric Mangini is the new head coach of the Cleveland Browns, a week after being fired by the New York Jets. A person with knowledge of the negotiations told The Associated Press that Mangini will be introduced Thursday at a news conference at the team's headquarters in Berea.

Israel bombards Gaza, U.S. backs ceasefire plan (Reuters)

Reuters - Israeli warplanes bombed the Gaza Strip on Thursday and tanks pounded Palestinian guerrillas on the ground as U.S. backing for a proposed truce raised expectations of an end to the offensive.

Senate Democrats move to seat Burris (Reuters)

Reuters - In an abrupt switch, Democratic leaders began talks on Wednesday to swear in Roland Burris, appointed by embattled Illinois Gov. Rod Blagojevich to replace President-elect Barack Obama in the U.S. Senate.

Budget deficit to hit $1.2 trillion in fiscal 2009 (Reuters)

Reuters - The U.S. budget deficit will swell to a record $1.186 trillion in fiscal 2009, congressional forecasters said on Wednesday, the result of an economic recession that has cut tax receipts and caused massive government bailouts of banks and automakers.

Mumbai-like attack could happen in U.S.: Bush aide (Reuters)

Reuters - U.S. cities are vulnerable to an attack like the gun-and-grenade assault that terrorized Mumbai for three days and killed 179 people, the White House homeland security adviser said on Wednesday.

"Enemy combatant" will be early test for Obama (Reuters)

Reuters - The case of Ali al-Marri, accused of being an al Qaeda "sleeper" agent and held for 5-1/2 years at a U.S. military prison in South Carolina, will be an early test for President-elect Barack Obama.

Salmonella outbreak sickens 388 across U.S.: health officials (Reuters)

Reuters - An outbreak of salmonella food poisoning has made 388 people sick across 42 states, sending 18 percent of them to the hospital, U.S. health officials said on Wednesday.

U.S. presses to jail Madoff on diamonds, watches mail (Reuters)

Reuters - Accused swindler Bernard Madoff should be jailed for violating a court order by mailing $1 million worth of diamonds, watches and other jewelry to friends and family, U.S. prosecutors told a court on Wednesday.

Russia, Ukraine take gas row case to Europe (Reuters)

Reuters - Russia and Ukraine argue their case to Europe on Thursday in a gas price dispute that has choked off energy supplies to EU countries beset by bitter winter weather.

Israel approves tougher war on Hamas (AFP)

AFP - Israel on Wednesday approved an even tougher war on Hamas, warning residents to flee southern Gaza ahead of planned bombing of cross-border tunnels, as the Palestinian death toll passed 700.

Russia, Ukraine in EU talks as gas crisis engulfs Europe (AFP)

AFP - Envoys from Russia and Ukraine go to Brussels on Thursday for emergency EU-brokered talks to resolve a bitter gas fight between the two ex-Soviet giants that has engulfed Europe in a major energy crisis.

Single hung aluminum window glass repair

Home Improvement Home Improvement