How to Remove Your Mk2 Mini Moto Engine

Home
>
Motorcycle
>
How to Remove Your Mk2 Mini Moto Engine

How to Remove Your Mk2 Mini Moto Engine

Many mini moto modifications will require you to remove the engine from the mini moto. This is why I have produced the following guide.

Firstly you will need to remove the mini moto's fairing.

Start with the seat fairing, unscrew the four seat screws and remove the seat. Unscrew the screw at the front end of the seat fairing and remove the petrol cap. The fairing can now be lifted from the mini moto. Replace the fuel tank petrol cap and remove the fuel tank by pulling the rubber tube of the nipple on the top of the carburettor. You may want to double the rubber fuel tube over and secure it in this position with a clothes peg. This is to stop fuel leaking out.

Remove the bottom fairing by unscrewing the holding bolts (two on each side), this frees the bottom fairing from the top. Unscrew the two bolts on the underside of the bottom fairing. The bottom fairing is now free. The top fairing is only now held on by one last bolt located in between the handle bars at the front of the mini moto.

Once you have removed the fairing, you will need to take the chain off the front sprocket. To do this loosen the back wheel nuts and the tensioning bolts. The back wheel can now be manoeuvred toward the front sprocket loosing the chain. When the chain is loose enough you can remove it from the front sprocket.

Remove the pull start from the engine by unscrewing the three holding screws. Once the pull start has been removed you will see the wire that comes from the stop switch. Unplug this.

The throttle cable can be removed from its fitting on the top of the carburettor. Pull the rubber seal up so that the locking nut can be unscrewed, the throttle can now be pulled from the carburettor along with the needle valve and spring.

The next step is to Remove the Exhaust. The exhaust is fixed to the mini motos frame by a bolt located just under the seat fairing toward the back of your mini moto. Undo this bolt with a spanner and an alan key. The exhaust is fixed to the underside of the engine by two bolts via a gasket. Remove the two bolts with an alan key making sure that you do not lose the gasket washer. The exhaust can now be slid out past the engine and removed form the mini moto.

The engine is free from its mechanical fittings, the engine then needs to be removed from the mini motos frame. The bolt at the top of the engine must be undone first using the alan key. The three screws located on the underside of the engine are the last fixings to be undone. The engine can now be completely removed from the mini moto.

Matt Tong has been importing and riding Mini Motos for two years. For expert advice and Mini Moto information please visit http://www.minimotosandmore.com

In The News:

Yahoo! News: Top Stories

Rice arrives in India in wake of Mumbai attacks (AP)

AP - Secretary of State Condoleezza Rice arrived in New Delhi on Wednesday as part of a U.S. effort to ease tensions in the region after a three-day terrorist attack killed 171 people in India's financial capital.

Dems' hopes for Senate supermajority dashed in Ga. (AP)

AP - Relieved Republicans celebrated a resounding win in Georgia's hard-fought U.S. Senate runoff, a victory that denied Democrats a filibuster-proof majority and cemented the state's reputation as a GOP bastion.

Gates: Military looks to accelerate Iraq pullout (AP)

AP - Defense Secretary Robert Gates signaled a willingness Tuesday to forge ahead with two key priorities for the incoming Obama administration: accelerating the U.S. withdrawal from Iraq and shutting down the Guantanamo Bay detention center.

Auditors fault Treasury oversight of bailout funds (AP)

AP - The government must toughen its monitoring of the $700 billion financial bailout to ensure that banking institutions limit their top executives' pay and comply with other restrictions, federal auditors said Tuesday in the first comprehensive review of the rescue package.

2 arrested in alleged torture of teen, who escaped (AP)

AP - A Girl Scout leader and her husband were arrested after an emaciated, terrified and nearly naked 17-year-old showed up at a gym with a chain locked to his ankle, saying he had just fled his captors, authorities said Tuesday.

Divorce rate increases in Marine Corps, Army (AP)

AP - The divorce rate among soldiers and Marines increased last year as military marriages suffered continuing stress from America's two ongoing wars. There were an estimated 10,200 failed marriages in the active duty Army and 3,077 among Marines, according to figures obtained by The Associated Press for the budget year ended Sept. 30.

Study flunks 49 states in college affordability (AP)

AP - An independent report on American higher education flunks all but one state when it comes to affordability an embarrassing verdict that is unlikely to improve as the economy contracts.

American folk music legend Odetta dies at 77 (AP)

AP - Odetta, the folk singer with the powerful voice who moved audiences and influenced fellow musicians for a half-century, has died. She was 77.

Most Asian markets rise after Wall Street rebound (AP)

AP - Asian stock markets mostly rose Wednesday after a rebound on Wall Street, but pervasive concerns about the dismal outlook for the world economy limited gains.

Murphy's tip in lifts Pacers over Lakers, 118-117 (AP)

AP - Danny Granger scored 32 points and led Indiana back from a 15-point fourth-quarter deficit, and Troy Murphy tipped in a missed shot at the buzzer to complete an improbable 118-117 victory over the Los Angeles Lakers on Tuesday night.

Rice arrives in India to ease tension with Pakistan (Reuters)

Reuters - Secretary of State Condoleezza Rice arrived in New Delhi on Wednesday as part of urgent U.S. efforts to ease tension between India and Pakistan that has surged over the Mumbai attacks.

South Korea steps up crisis fight (Reuters)

Reuters - South Korea moved on Wednesday to help local banks through a cash crunch gripping the global financial system as central banks around the world were expected to cut interest rates again to support their fast flagging economies.

U.S. forces in Iraq detain, kill Iran-backed suspects (Reuters)

Reuters - U.S. forces in Iraq captured two suspected members of an Iranian-backed network and killed a third Wednesday, part of U.S. efforts to target a group it says has attacked Iraqi citizens and foreign troops.

Automakers' desperate bailout plea gaining support (Reuters)

Reuters - A top lawmaker predicted Washington would approve a bailout for U.S. automakers after they submitted survival plans, and General Motors Corp and Chrysler LLC said they needed an immediate infusion of cash to avoid failures.

Obama wrapping up cabinet picks with Richardson (Reuters)

Reuters - President-elect Barack Obama moved swiftly toward wrapping up his cabinet appointments on Wednesday with the selection of rival-turned-supporter Bill Richardson as secretary of commerce.

Republicans win crucial Georgia Senate seat (Reuters)

Reuters - Republican Sen. Saxby Chambliss easily won a run-off election in Georgia on Tuesday, denying Democrats the chance for a 60-seat "super majority" in the Senate that would have enabled them to pass legislation virtually at will.

Oil rises more than $1 (Reuters)

Reuters - Oil rose toward $48 a barrel on Wednesday, recovering from a tumble of more than $100 off July peaks, but the upside could be limited, with further signs of weakening oil demand expected in upcoming weekly U.S. oil data.

Clinton for a Clinton? Senate guessing game begins (Reuters)

Reuters - New York Gov. David Paterson has famous names to choose from in picking a replacement for Sen. Hillary Clinton, including a Kennedy, a Cuomo and even another Clinton, as in the former president of the United States.

Thai protesters abandon airports as flights due in (AFP)

AFP - Hundreds of anti-government protesters packed up and left Bangkok's airports on Wednesday after a crippling siege, as authorities assured angry tourists that flights would resume within 24 hours.

Rice arrives in India after Mumbai attacks (AFP)

AFP - US Secretary of State Condoleezza Rice arrived in New Delhi Wednesday to try and ease India-Pakistan tensions over the Mumbai attacks, as US intelligence blamed a Pakistan-based militant group.

How to Remove Your Mk2 Mini Moto Engine

Motorcycle Motorcycle