Know Your Mini Moto

Home
>
Motorcycle
>
Know Your Mini Moto

The Mini Moto is a small scale replica of the World Super Bikes used by the likes of Valentino Rossi and ex champion Carl Fogarty. The Mini Moto comes equipped with either a two stroke air or water cooled engine which are, depending on the model, capable of speeds of up to 60Mph.

In this article I will underline the finer points of the components that make these speeds possible.

The two Stroke Engine

The two stroke engine produces more hp per pound than the four stroke engine. The two stroke engine consists of three moving parts, the piston, the rod and the crank. The piston acts as valve that opens and closes the intake and exhaust ports that are located on the walls of the cylinder. Unlike the four stroke engine that fires only every other time of the pistons movement, the two stoke engine fires every time the piston reaches the top of its travel. This means that the time spent generating power is doubled in the two stroke engine than that of the four stroke engine, as there is no engine coasting during passive cycles. This is the main reason that the two stroke engine can rev more highly and produce more power (for its size) that the four stroke.

Fuel

The two stroke engine needs to be run on a mixture of petrol and two stroke oil. This is so that the engine is kept lubricated whilst in use.

99% of all starting problems are caused by fuel problems. These can stem from bad or old fuel and improperly mixed fuel (please see mixing chart). Do not use fuels that contain alcohol, as the can cause you bike to run 'lean'. Be advised some racing fuels contain alcohol and are best avoided.. We recommend that you use normal petrol for a garage and a quality two stroke oil.

A mixture that is too lean I.e not enough two stroke oil can damage your mini moto's engine as the moving parts are not properly lubricated. This can cause the engine to seize. However a mixture that is too rich can choke the engine and effect the performance and cause starting problems. You can tell if your mini moto is running too richly by the plumes of white smoke coming out of the exhaust and the lack of performance. A rich mixture (25:1) is needed to lubricate the engine during the 'run in' period, you may experience a lack of performance during this period. The pocket bike may run more slowly and acceleration can be sluggish, however when you change to a mixture of 50:1 you will really notice a difference. The leaner mix ignites in the combustion chamber faster and with a more explosive force than the richer mix. This means higher revs which means more power and acceleration.

We recommend that a fuel mixture of 25:1 is used to 'run in' you mini moto, and a mixture of 50:1 is used thereafter.

'Running in'

Your mini moto should be 'run in' for the first 3-4 tanks of fuel. During this period we recommend that you use a fuel mixture of 25:1. This means a mixture that is made up of 25 parts petrol to 1 part of two stroke oil. During the 'running in' period be careful to not rev the engine to its maximum as this can damage the engine. The 'running in' period will allow the moving parts to become well oiled and the clutch and brakes to 'bed' themselves in. After you have run the minimoto on this fuel mixture for 3-4 tanks, check the chain and tighten accordingly, check the tyre pressure, tighten the bolts on the brakes, forks and wheels. You may also need to readjust the throttle settings to allow for the higher revs that changing to a leaner fuel mix produces. The bike should now be ready for a fuel mixture of 50:1.

Clutch

The mini moto uses a centrifugal clutch to power the drive the sprocket, which in turn drives the back wheel of your mini moto.

When you start your mini moto the clutch spins as the engine ticks over . The clutch is engaged when you pull back on the throttle. The increase in speed of revolution of the clutch makes the clutch expand and grip the inside of the clutch bell which turns the sprocket that drives the back wheel of your pocket bike.

The clutch can be set up in different ways depending on the type of performance that you want from your minimoto. Adjustable clutches are not standard on mini moto's but an after market Polani or Blata style adjustable clutch can be used in your new mini moto. These allow the rider to adjust the mini moto's set up in according to their preference. Setting the clutch to engage too late when the engine has built up too much power may cause the clutch to slip and never fully engage. This can result in excessive wearing. However setting the clutch to engage too early, before the power has built up in the engine can cause your pocket bike to 'bog down', resulting in slow acceleration. The perfect set up is to get the clutch to engage just as the engine has built enough power to rocket the mini moto away, but without making the clutch slip, this is achievable through trial and error.

Spark Plug

Making sure that your spark plug is fresh is important in a two stroke mini moto engine. You can tell a lot from the colour of the spark plug. The top part of your spark plug is covered in ceramic insulator which, when brand new is white. This part of the spark plug can change colour according to how your engine is running. The plug should appear as a nice tan colour when the engine is running perfectly, this indicates complete combustion. A greyish or white colour indicates that the engine is running too lean which can result in engine damage. In this case you should clean and check your fuel system for any obstruction, check your fuel mixture, check for loose intake manifold bolts and carburettor mounting leeks, faulty gaskets and leaking crank seals. Anywhere that your engine could potentially leek and suck in fresh air can be the source of a lean condition.

A blackened or oily spark plug indicates improper combustion and is the result of running too rich. This can be caused by too much oil in the mixture or the spark plug could be faulty and misfiring. Check the fuel mixture and replace the spark plug.

Air Filter

Your new mini moto is equipped with an air filter. Some bikes such as the B1 Origami rep liquid cooled and the Mini Dirt bike have a 'cone' style K and N style air filter. The 2005 mk2 mini moto and the B1 Origami Replica air cooled bikes have a standard mini moto air filter. Both air filters purify the intake of air that is sucked into the carburettor. This means that the air filter should be cleaned regularly as the mini moto's performance can begin to suffer as the engine can become starved of air if the air filter is choked with debris. To reach the air filter, remove the bikes bottom fairing, remove the protective cover by unscrewing the holding screws. Clean the air filter in petrol but make sure that the filter is dry before reattaching to you mini moto.

Tyres

The tyres on your mini moto are filled with air (pneumatic). Please consult your mini moto handbook for the appropriate psi. It is important to check the tyre pressure regularly, an under inflated tyre will affect the performance of your mini moto, acceleration can become sluggish and cornering can become dangerous.

Chain

Before riding your mini moto you need to make sure that the front and back sprockets are aligned and that the chain is perfectly straight running between them. Once you have established this make sure that the chain is tensioned correctly (please see your mini moto handbook). To test the tension of the chain you can manually push the pocket bike, if you hear a 'pinging' or 'popping' sound the chain is too loose. If the chain is noisy and starts to bind the chain is too tight. Make sure that the chain is well oiled. The chain needs to be oiled before every ride.

Gearing

The gearing of you mini moto is dictated by the number of the teeth on the front sprocket and on the back sprocket. The sprockets can be changed as an easy way to manipulate top end speed and acceleration, quite like changing gear on a mountain bike. A front sprocket with more teeth will improve acceleration, however the top end speed will be reduced. A larger rear sprocket will produce a higher top speed but acceleration will suffer. The gearing on your bike can be adjusted in accordance for the track you are intending to ride I.e. a small track with a lot of bends will suit gearing for improved acceleration, however a track with long straights will require a mini moto that is geared for a higher top speed.

Throttle

The throttle on your new mini moto is a 'twist grip' style throttle. When you twist the throttle the throttle cable is pulled back revving the engine. It is important to keep this cable free from obstacles and clean. If the throttle begins to feel 'loose' of 'gives', the tension of the cable can be adjusted via the adjusting screw.

Brakes

The brake system comprises of brake levers, brake cables, brake callipers and brake discs.

The brakes on your mini moto are operated by levers found on the handle bars. The right hand brake controls the front brake, and the left controls the back brake. Pulling on the handle pulls the brake cable which in turn pulls the lever located on the bake calliper. This action pushes the brake discs towards each other. This creates friction on the brake disc which slows down or stops the bike.

The brakes can be adjusted in the following ways.

The brake cable can be tensioned using the adjustment screw found on the brake lever. Unscrew the locking nut, twist the screw to reach the desired tension. Re screw the locking nut.

This is a two person job. Adjust the screw on the hand brake so that is at the end of its travel. Undo the clamp that holds the brake cable on the lever located on the brake calliper. One person needs to push the lever forward as far as it will, the second person needs to pull back on the brake cable and re fasten the clamp. The crake cable will now be highly tensioned.

Pull Start

To start the mini moto pull slowly to turn the fly wheel. This pumps some fuel around the engine, which lubricates the moving parts. Pull the pull start firmly in order to start the engine. Important, do not pull the cord to the end of its run as it can break. If the mini moto does not start check the choke and the throttle cable.

Choke

The choke controls the amount of air that is allowed into the air/fuel mix. The choke is adjusted via a lever located on the side and back of the engine. The choke is off when the lever is down, and on when the lever is up. When you start the mini moto the choke should be on, when the mini moto is warm and ready to ride the choke needs to be off.

Carburettor

It is recommend that any adjustments to the carburettor are made by a professional. The carburettor pumps and mixes the fuel and air. The small diaphragms, orifices and ports mix the air and fuel very precisely, this process demands clean fresh fuel.

Jet

The jet can be adjusted by the screw located in the access hole to the right of the choke lever. The jet is adjusted by the manufacture however the conditions of where you wish to ride may be different, which means that you will need to make adjustments. Turning the screw clockwise will make the bike run with a leaner mixture, and counter clockwise will richen the mixture. Only adjust the screw 1 tern a at time and then test the mini moto, this is trail and error. Please note that it is best to find the optimum setting for performance and then run a slightly richer mixture as a mix that is too lean can seize the engine.

Matt Tong has been importing and riding Mini Motos for over two years. For more information please visit http://www.minimotosandmore.com

In The News:

Yahoo! News: Top Stories

Georgia Sen. Chambliss wins re-election in runoff (AP)

AP - Georgia Republican Sen. Saxby Chambliss handed the GOP a firewall against Democrats eager to flex their newfound political muscle in Washington, winning a bruising runoff battle Tuesday night that had captured the national limelight.

Rice arrives in India in wake of Mumbai attacks (AP)

AP - Secretary of State Condoleezza Rice arrived in New Delhi on Wednesday as part of a U.S. effort to ease tensions in the region after a three-day terrorist attack killed 171 people in India's financial capital.

Gates: Military looks to accelerate Iraq pullout (AP)

AP - Defense Secretary Robert Gates signaled a willingness Tuesday to forge ahead with two key priorities for the incoming Obama administration: accelerating the U.S. withdrawal from Iraq and shutting down the Guantanamo Bay detention center.

Auditors fault Treasury oversight of bailout funds (AP)

AP - The government must toughen its monitoring of the $700 billion financial bailout to ensure that banking institutions limit their top executives' pay and comply with other restrictions, federal auditors said Tuesday in the first comprehensive review of the rescue package.

2 arrested in alleged torture of teen, who escaped (AP)

AP - A Girl Scout leader and her husband were arrested after an emaciated, terrified and nearly naked 17-year-old showed up at a gym with a chain locked to his ankle, saying he had just fled his captors, authorities said Tuesday.

Divorce rate increases in Marine Corps, Army (AP)

AP - The divorce rate among soldiers and Marines increased last year as military marriages suffered continuing stress from America's two ongoing wars. There were an estimated 10,200 failed marriages in the active duty Army and 3,077 among Marines, according to figures obtained by The Associated Press for the budget year ended Sept. 30.

Newly released Nixon-era memo shows aides dishing dirt on critics (AP)

AP - In Richard Nixon's time, all the president's men fretted about threats on every front: disquiet out on the streets, disloyalty inside the administration and trouble from political opponents who had to be discredited at any cost.

Study flunks 49 states in college affordability (AP)

AP - An independent report on American higher education flunks all but one state when it comes to affordability an embarrassing verdict that is unlikely to improve as the economy contracts.

Beyonce to perform at Essence Fest in New Orleans (AP)

AP - Beyonce is the first artist lined up for next year's Essence Music Festival in New Orleans.

Murphy's tip in lifts Pacers over Lakers, 118-117 (AP)

AP - Danny Granger scored 32 points and led Indiana back from a 15-point fourth-quarter deficit, and Troy Murphy tipped in a missed shot at the buzzer to complete an improbable 118-117 victory over the Los Angeles Lakers on Tuesday night.

Rice arrives in India to ease tension with Pakistan (Reuters)

Reuters - Secretary of State Condoleezza Rice arrived in New Delhi on Wednesday as part of urgent U.S. efforts to ease tension between India and Pakistan that has surged over the Mumbai attacks.

South Korea steps up crisis fight (Reuters)

Reuters - South Korea moved on Wednesday to help local banks through a cash crunch gripping the global financial system as central banks around the world were expected to cut interest rates again to support their fast flagging economies.

Automakers' desperate bailout plea gaining support (Reuters)

Reuters - A top lawmaker predicted Washington would approve a bailout for U.S. automakers after they submitted survival plans, and General Motors Corp and Chrysler LLC said they needed an immediate infusion of cash to avoid failures.

Obama wrapping up cabinet picks with Richardson (Reuters)

Reuters - President-elect Barack Obama moved swiftly toward wrapping up his cabinet appointments on Wednesday with the selection of rival-turned-supporter Bill Richardson as secretary of commerce.

Republicans win crucial Georgia Senate seat (Reuters)

Reuters - Republican Sen. Saxby Chambliss easily won a run-off election in Georgia on Tuesday, denying Democrats the chance for a 60-seat "super majority" in the Senate that would have enabled them to pass legislation virtually at will.

Pentagon chief Gates backs Obama Iraq policy (Reuters)

Reuters - U.S. Defense Secretary Robert Gates, who will stay on under Barack Obama, said on Tuesday he supported the president-elect's Iraq policy but declined to back his proposed timetable for the withdrawal of U.S. forces.

Oil rises more than $1 (Reuters)

Reuters - Oil rose toward $48 a barrel on Wednesday, recovering from a tumble of more than $100 off July peaks, but the upside could be limited, with further signs of weakening oil demand expected in upcoming weekly U.S. oil data.

Clinton for a Clinton? Senate guessing game begins (Reuters)

Reuters - New York Gov. David Paterson has famous names to choose from in picking a replacement for Sen. Hillary Clinton, including a Kennedy, a Cuomo and even another Clinton, as in the former president of the United States.

Thai protesters abandon airports as flights due in (AFP)

AFP - Hundreds of anti-government protesters packed up and left Bangkok's airports on Wednesday after a crippling siege, as authorities assured angry tourists that flights would resume within 24 hours.

Rice arrives in India after Mumbai attacks (AFP)

AFP - US Secretary of State Condoleezza Rice arrived in New Delhi Wednesday to try and ease India-Pakistan tensions over the Mumbai attacks, as US intelligence blamed a Pakistan-based militant group.

Know Your Mini Moto

Motorcycle Motorcycle