Mini Moto Tips

Home
>
Motorcycle
>
Mini Moto Tips

These are some quick adjustments and tips for the B1 liquid cooled minimoto that I have found helpful.

Extra heat protection:

To protect the bike I've put some aluminium tape on the inside of the fairing at the closest point to the exhaust and on the underside of the fuel tank. I?ve done this because the engine gets so hot I wanted to protect the fairing from melting, and it doesn't hurt to protect the fuel tank for the same reasons!

My cooling system tips:

When you run out of cooling liquid for your B1 rep, use is distilled water which is available at your local garage, add some food colouring to it so that you can easily tell the level and away you go.

Only fill the reservoir to a quarter full, this is easily enough coolant and it leaves room for the pressure.

Once you have filled the coolant reservoir, there is often air locks in the system. To get rid of these start the bike and allow it to warm up, then bounce the bike (gently) on its back tyre with the bike vertical. Do this a few times, this should get rid of the air locks in the system and prevent overheating. The coolants level may need to be topped up now.

Where not to ride:

Hi just bought my new B1 air cooled from you guys. Thanks it's a great bike. A quick word of advice for your other customers. DO NOT RIDE YOUR MINI MOTO ON THE ROAD. My friend (who also rides a mini moto, but on tracks where they are supposed to be ridden!) is a police man (boooo!) and the law is very strict:

The driver or rider of a motorised board or cycle on a road could face heavy fines, endorsement of licence, disqualification and in the case of dangerous driving, up to 2 years imprisonment.

Remember that the term road includes not only a carriageway but also pavements and verges and also any highway which encompasses footpaths, bridleways and by-ways.

It can also include privately owned roads to which the public have access and has in some cases included car parks?

Car park warriors beware!!!???

Here's a good tip. Before riding your mini moto you will need to make sure that your wheels and chain are aligned. Here's how. Loosen the bolts on the back wheel so that you can move it. Place a piece of perfectly straight wood (I used a meter stick) up against the front wheel. When the front wheel is straight the meter stick should be flush against both the front of the tyre and the back. Then it's a simple case of lining up the back wheel. The chain should now also be straight.

Changing the gearing on your mini moto is simple. A bigger front sprocket combined with a smaller rear sprocket creates a smaller ratio, this means that the mini moto will have better accelelaration but less top spead. A smaller front sprocket with a bigger back sprocket will give your mini moto a better top speed but slower acceleration.

Here are the possible variations of gearing: The lower the ratio the faster acceleration. The higher ratio, the better the top speed.

8/54 6.75>1
8/56 7>1
8/58 7.25>1
8/60 7.5>1
7/54 7.714285714>1
8/62 7.75>1
7/56 8>1
8/64 8>1
7/56 8>1
8/66 8.25>1
7/58 8.285714286>1
8/68 8.5>1
7/60 8.571428571>1
8/70 8.75>1
7/62 8.857142857>1
8/72 9>1
6/54 9>1
7/64 9.142857143>1
8/74 9.25>1
6/56 9.333333333>1
7/66 9.428571429>1
8/76 9.5>1
6/58 9.666666667>1
7/68 9.714285714>1
8/78 9.75>1
6/60 10>1
7/70 10>1
7/72 10.28571429>1
6/62 10.33333333>1
7/74 10.57142857>1
6/64 10.66666667>1
7/76 10.85714286>1
6/66 11>1
7/78 11.14385714>1
6/68 11.33333333>1
6/70 11.66666667>1
6/72 12>1
6/74 12.33333333>1
6/76 12.66666667>1
6/78 13>1

I tried 7/56 with my B1 Rep at GP Karting, I think that this is just about right for that track as it has lotts of tight corners. Might go to Stretton soon so I can try my 7/68 setup. This should be good for the straights however it may take a while to get up to speed!!

Matt Tong has been importing and riding Mini Motos for two years. For expert advice and Mini Moto information please visit http://www.minimotosandmore.com

In The News:

Yahoo! News: Top Stories

Georgia Sen. Chambliss wins re-election in runoff (AP)

AP - Georgia Republican Sen. Saxby Chambliss handed the GOP a firewall against Democrats eager to flex their newfound political muscle in Washington, winning a bruising runoff battle Tuesday night that had captured the national limelight.

Rice arrives in India in wake of Mumbai attacks (AP)

AP - Secretary of State Condoleezza Rice arrived in New Delhi on Wednesday as part of a U.S. effort to ease tensions in the region after a three-day terrorist attack killed 171 people in India's financial capital.

Gates: Military looks to accelerate Iraq pullout (AP)

AP - Defense Secretary Robert Gates signaled a willingness Tuesday to forge ahead with two key priorities for the incoming Obama administration: accelerating the U.S. withdrawal from Iraq and shutting down the Guantanamo Bay detention center.

Auditors fault Treasury oversight of bailout funds (AP)

AP - The government must toughen its monitoring of the $700 billion financial bailout to ensure that banking institutions limit their top executives' pay and comply with other restrictions, federal auditors said Tuesday in the first comprehensive review of the rescue package.

2 arrested in alleged torture of teen, who escaped (AP)

AP - A Girl Scout leader and her husband were arrested after an emaciated, terrified and nearly naked 17-year-old showed up at a gym with a chain locked to his ankle, saying he had just fled his captors, authorities said Tuesday.

Divorce rate increases in Marine Corps, Army (AP)

AP - The divorce rate among soldiers and Marines increased last year as military marriages suffered continuing stress from America's two ongoing wars. There were an estimated 10,200 failed marriages in the active duty Army and 3,077 among Marines, according to figures obtained by The Associated Press for the budget year ended Sept. 30.

Newly released Nixon-era memo shows aides dishing dirt on critics (AP)

AP - In Richard Nixon's time, all the president's men fretted about threats on every front: disquiet out on the streets, disloyalty inside the administration and trouble from political opponents who had to be discredited at any cost.

Study flunks 49 states in college affordability (AP)

AP - An independent report on American higher education flunks all but one state when it comes to affordability an embarrassing verdict that is unlikely to improve as the economy contracts.

Beyonce to perform at Essence Fest in New Orleans (AP)

AP - Beyonce is the first artist lined up for next year's Essence Music Festival in New Orleans.

Murphy's tip in lifts Pacers over Lakers, 118-117 (AP)

AP - Danny Granger scored 32 points and led Indiana back from a 15-point fourth-quarter deficit, and Troy Murphy tipped in a missed shot at the buzzer to complete an improbable 118-117 victory over the Los Angeles Lakers on Tuesday night.

Rice arrives in India to ease tension with Pakistan (Reuters)

Reuters - Secretary of State Condoleezza Rice arrived in New Delhi on Wednesday as part of urgent U.S. efforts to ease tension between India and Pakistan that has surged over the Mumbai attacks.

South Korea steps up crisis fight (Reuters)

Reuters - South Korea moved on Wednesday to help local banks through a cash crunch gripping the global financial system as central banks around the world were expected to cut interest rates again to support their fast flagging economies.

Automakers' desperate bailout plea gaining support (Reuters)

Reuters - A top lawmaker predicted Washington would approve a bailout for U.S. automakers after they submitted survival plans, and General Motors Corp and Chrysler LLC said they needed an immediate infusion of cash to avoid failures.

Obama wrapping up cabinet picks with Richardson (Reuters)

Reuters - President-elect Barack Obama moved swiftly toward wrapping up his cabinet appointments on Wednesday with the selection of rival-turned-supporter Bill Richardson as secretary of commerce.

Republicans win crucial Georgia Senate seat (Reuters)

Reuters - Republican Sen. Saxby Chambliss easily won a run-off election in Georgia on Tuesday, denying Democrats the chance for a 60-seat "super majority" in the Senate that would have enabled them to pass legislation virtually at will.

Pentagon chief Gates backs Obama Iraq policy (Reuters)

Reuters - U.S. Defense Secretary Robert Gates, who will stay on under Barack Obama, said on Tuesday he supported the president-elect's Iraq policy but declined to back his proposed timetable for the withdrawal of U.S. forces.

Oil rises more than $1 (Reuters)

Reuters - Oil rose toward $48 a barrel on Wednesday, recovering from a tumble of more than $100 off July peaks, but the upside could be limited, with further signs of weakening oil demand expected in upcoming weekly U.S. oil data.

Clinton for a Clinton? Senate guessing game begins (Reuters)

Reuters - New York Gov. David Paterson has famous names to choose from in picking a replacement for Sen. Hillary Clinton, including a Kennedy, a Cuomo and even another Clinton, as in the former president of the United States.

Thai protesters abandon airports as flights due in (AFP)

AFP - Hundreds of anti-government protesters packed up and left Bangkok's airports on Wednesday after a crippling siege, as authorities assured angry tourists that flights would resume within 24 hours.

Rice arrives in India after Mumbai attacks (AFP)

AFP - US Secretary of State Condoleezza Rice arrived in New Delhi Wednesday to try and ease India-Pakistan tensions over the Mumbai attacks, as US intelligence blamed a Pakistan-based militant group.

Mini Moto Tips

Motorcycle Motorcycle